Content

Your car Toyota Corolla

• Introduction
• Safety first!
• Troubleshooting an emergency
• If the engine does not start and the starter motor does not scroll
• If the engine does not start and the starter motor rotates normally
• Starting the engine from an additional power source
• Wheel replacement
• Leak detection
• Towing
• Weekly checks
• Checks under the hood of the car
• Engine oil level
• Coolant level
• Brake fluid level
• Washer fluid level
• Tire condition and air pressure
• Windshield wipers
• Battery
• Electrical systems
• Working fluids and lubricants
• Tire pressure

• General view of the dashboard
• Signal indicators on the dashboard
• General view of the instrument panel
• Sensors and pointers
• Operation of instruments and controls
• Fuses

• General information
• Regular maintenance
• Replacement of engine oil and filter
• Checking hoses and leaks of working fluids
• Checking the drive shaft anther
• Lubrication of awnings and locks
• Replacement and check of a level of a working liquid of an automatic transmission
• Checking and replacing the auxiliary drive belt
• Replacement and inspection of the air filter
• Checking and adjusting the parking brake
• Checking brake pads
• Checking the suspension and exhaust system
• Checking the steering and suspension system
• Checking and adjusting the clutch pedal
• Checking the particle filter
• Road test
• Checking the parking brake pads
• Replacing the batteries of the control panel
• Brake fluid replacement
• Replacing coolant
• Replacement and check of oils level
• Replacement of spark plugs
• Checking and adjusting the valve clearance

• General information
• Regular maintenance
• Replacement of engine oil and filter
• Checking hoses and leaks of working fluids
• Checking the drive shaft anther
• Lubrication of awnings and locks
• Replacement and check of oils level
• Checking and replacing the auxiliary drive belt
• Replacement and inspection of the air filter
• Checking and adjusting the parking brake
• Checking brake pads
• Check of suspensions and pipelines of system of release of the fulfilled gases
• Checking the steering and suspension system
• Checking and adjusting the clutch pedal
• Checking the particle filter
• Road test
• Replacing the fuel filter
• Checking the parking brake pads
• Replacing the batteries of the control panel
• Brake fluid replacement
• Replacing coolant
• Checking and replacing the hose and valve of the crankcase ventilation system
• Checking and adjusting the valve clearance
• Replacing the timing belt

• General information
• Compression check
• The top dead center of the piston of the first cylinder
• Cylinder head cover - removal and installation
• Chain of timing and sprocket drive -replacement, inspection and installation
• Variable timing components (VVT-i) - removal, inspection and installation
• Right crankshaft oil seal - replacement
• Camshafts and pushers - removal, inspection and installation
• Cylinder head - removal and installation
• Oil pan - removal and installation
• Oil pump - removal, inspection and installation
• Engine oil pressure sensor - replacement
• Flywheel - removal, inspection and installation
• Crankshaft oil seal - replacement
• Engine / gearbox mountings - check and replace

• General information
• Procedures that can be performed without removing the engine from the engine compartment
• The top dead center of the piston of the first cylinder
• Cylinder head cover - removal and installation
• Intake manifold - removal and installation
• Exhaust manifold - removal and installation
• Timing belt and sprockets - removal, inspection and installation
• Right crankshaft oil seal - replacement
• Right camshaft seal - replacement
• Camshafts and pushers - removal and installation
• Cylinder head - removal and installation
• Oil pan - removal and installation
• The upper shell of the oil pump and the pallet - removal, inspection and installation
• Flywheel - removal and installation
• Crankshaft oil seal - replacement
• Engine supports - checking and replacing

• General information
• Major engine repairs - general information
• Engine removal - methods and precautions
• Engine - removal and installation
• Alternative engine replacement
• Engine overhauling - sequence of disassembly
• Cylinder head - disassembly
• Cylinder head and valves - cleaning and checking
• Valves - maintenance
• Cylinder head - assembly
• Piston / connecting rod assembly - removal
• Crankshaft removal
• Cylinder block - cleaning
• Cylinder block - check
• Piston / connecting rod assembly - check
• Crankshaft check
• The main bearing and the lower end of the connecting rod - check
• Engine overhaul - assembly sequence
• Piston rings - installation
• Crankshaft - installation
• Pistons / connecting rods - installation
• The engine is the beginning of traffic after major repairs

• General information
• Coolant / antifreeze - general information
• Thermostat - check and replace
• Engine cooling fan and relay - check and replace
• Radiator - removal and installation
• Water pump - check
• Water pump - removal and installation
• Coolant temperature transmitter - check and replace
• Motor fan resistor and fan motor - replacement
• Heatsink radiator - removal and installation
• Control unit for air conditioning and heater - removal and installation
• Air conditioning and heating system - check and maintenance
• Receiver / dehumidifier of air conditioning system - removing and installing
• Air conditioning compressor - removal and installation
• Air conditioning condenser - removing and installing
• Evaporator of air conditioning system - removal and installation
• Air conditioning sensors - replacement

• General information
• Fuel injection system - pressure relief
• Fuel pump - removal and installation
• Fuel level transmitter - check and replace
• Fuel lines and fittings - check and replace
• Fuel tank - removal and installation
• Fuel tank cleaning and repair - general information
• Air filter assembly - removing and installing
• Throttle cable - removal, installation and adjustment
• Fuel injection system - general information
• Fuel injection system - check and adjustment
• Fuel injection system - component testing and replacement
• Intake manifold - removal and installation
• Exhaust manifold - removal and installation
• Exhaust system - removal and installation

• General information
• Fuel lines and fittings - general information
• Fuel level transmitter - removing and installing
• Fuel tank - removal and installation
• Cleaning and repair of the fuel tank
• Air filter and intake system - removing and installing
• Fuel filter - removal, replacement and installation
• High-pressure fuel pump (injection pump) - check, removal and installation
• Common rail system for high pressure - removal and installation
• High pressure fuel lines - removal and installation
• Nozzles - check, remove and install
• On-board diagnostic system and DTCs
• Electrical components of the fuel injection system - check, remove and install
• Turbocharger - check, removal and installation
• Intercooler - removing and installing
• Exhaust system - removal and installation

• General information
• Fuel vapor recovery system (EVAP)
• System of forced ventilation of crankcase (PCV)
• Catalytic converter

• General information
• Crankcase ventilation system - general information
• Exhaust gas recirculation system - checking, removing and installing

• General information
• Battery - check and charge
• Battery - removal and installation
• Recharging system - general information and precautions
• Charge system - check
• Generator - removal and installation
• Alternator regulator / brush holder - replacement
• Generator - check and overhaul
• Start-up system - general information and precautions
• Starter - check in the car
• Starter - removal and installation
• Glow plug system (diesel engines) - general information
• Glow plugs (diesel engines) - check and replace

• General information
• Ignition coil - replacement
• Detonation sensor - removal, inspection and installation

• General information
• Hydraulic clutch system - bleeding pressure
• Clutch components - removal, inspection and installation
• Clutch release bearing and lever - removal, inspection and replacement
• Clutch master cylinder - removal, overhaul and installation
• Clutch slave cylinder - removal, overhaul and installation
• Clutch pedal position sensor - check and replace

• General information
• Gear shift cables - removing and installing
• Gear lever - removal and installation
• Back-up light switch - check and replace
• Manual gearbox - removing and installing
• Major overhaul of a manual transmission - general information
• Oil seals - replacement

• General information
• Diagnostics - general information
• Replacing the gland
• Switching cable - removal, installation and adjustment
• System for locking the selector lever in P or N mode - removal, installation and adjustment
• Transmission supports - check and replace
• Automatic gearbox - removal and installation

• Drive shafts - general information
• Drive shafts - removal and installation
• Replacement of an anther of a power shaft and Shrus check

• General information
• Hydraulic system - air removal
• Hydraulic connections and hoses
• Front brake pads are replacement
• Rear brake pads - replacement
• Front disc brake - checking, removing and installing
• Rear disc brake - removal, inspection and installation
• Front brake caliper - removal, overhaul and installation
• Rear brake caliper - removal, overhaul and installation
• Brake shoes - replacement
• Master brake cylinder - removal, overhaul and installation
• Brake pedal - removal and installation
• Vacuum brake booster - checking, removing and installing
• The check valve of the vacuum amplifier of brakes - removal, check and installation
• Parking brake - adjustment
• Parking brake lever - removal and installation
• Parking brake cables - removal and installation
• Brake light switch - removal, installation and adjustment
• Vacuum pump (diesel engines) - check, removal and installation
• Anti-lock braking system (ABS) - general information
• Anti-lock components (ABS) - removal and installation

• General information
• The front suspension bracket assembly - removal, inspection and installation
• Rack / spring assembly - replacement
• Stabilizers of lateral stability and the plug (forward) - removal and installation
• Suspension lever - removal, inspection and installation
• Ball bearings - replacement
• Hub carrier and hub assembly (front) - removal and installation
• Hub and bearing assembly (front) - removing and installing
• Stabilizer of transverse stability (rear) - removal and installation
• Rear suspension bracket assembly - removal, inspection and installation
• Stabilizer bar for lateral stability - removal and installation
• Bearing and hub assembly (rear) - removal and installation
• Rear axle - removal and installation
• Steering system - general information
• Steering wheel - removal and installation
• The ends of the tie rod - removal and installation
• Anthers of the steering rack - replacement
• Steering rail - removal and installation
• Steering column and servo - removal and installation
• Wheels and tires - general information
• Wheel alignment - general information

• General information
• Maintenance - body and frame
• Maintenance - upholstery and rugs
• Elimination of minor body damage - repairs
• Elimination of serious damage to the body - repair
• Front bumper - removal and installation
• Rear bumper - removal and installation
• Hood - removal, installation and adjustment
• A cable of blocking and opening of a cowl - removal and installation
• Hood lock - removal and installation
• Radiator grille - removal and installation
• Door - removal, installation and adjustment
• Internal door trim panel - Removing and installing
• Door handle and lock components - removal and installation
• Door window and window lift - removal and installation
• Luggage compartment lid and lock components - removal and installation
• The luggage compartment door, the components of the lock and the support pillars - removal and installation
• Components of the central lock - removal and installation
• Components of electric glass lifts - removal and installation
• Mirrors and their components - removal and installation
• Windscreen, fixed glass, rear window / tailgate window - general information
• Hatch - general information and servo replacement
• External components of the body - removal and installation
• Seats - removal and installation
• Seat belt pretensioner mechanism - general information
• Components of seat belts - removal and installation
• Internal lining - removal and installation
• Central console - removal and installation
• Complete trim panels - removal and installation

• General information
• Detection of malfunctions in the electrical system - general information
• Fuses and relays - general information
• Switches - removal and installation
• Dashboard - removal and installation
• The control unit of direction indicators / light alarm - replacement
• Lamps (external lighting) - replacement
• Lamps (interior lighting) - replacement
• External headlamps - removal and installation
• Headlamps height - check and adjustment
• Servo drive for headlights - removal and installation
• Acoustic signal - replacement
• Washer system components - removal and installation
• Wiper arm - removal and installation
• Servo and windshield wiper retractor - removing and installing
• Rear window wiper motor - removing and installing
• Audio system - removal and installation
• Speakers - removal and installation
• Passive safety system - general information and precautions
• Airbag system - component replacement
• Electrical diagrams - general information

• Overall dimensions and weight
• Fuel consumption
• Vehicle identification numbers
• General repair procedures
• Lifting the car with a jack and the point of the pillars
• Tools and devices
• Technical condition check
• Troubleshooting
• Glossary