Content

Introduction

Actions in emergency situations

• In case of an emergency
• If you need to stop the car urgently
• If the car needs towing
• If there is any doubt
• Fuel pump disconnect system (gasoline engine only)
• If the control lamp is lit or a warning tone is sounded
• If you see a warning message
• Checking and replacing fuses
• If the wheel (cars with spare wheel) is deflated
• If the wheel is released (cars with emergency repair kit to eliminate the puncture)
• If the transmission control lever can not be removed from the "P" position "(Only for versions with automatic transmission)
• If the electronic key does not work properly (auto-intelligent with intelligent input and start system )
• Starting the engine from an external power source
• If the engine of the car has overheated
• If the fuel runs out and the engine stalls (only the diesel engine)
• If the car is bogged down
• Replacing lamps

Daily checks and troubleshooting

Operation of the car in the winter

Trip to the RST

Operation and maintenance manual

• Technical information of the car
• Controls, dashboard, salon equipment
• Caring for the car body and interior
• Vehicle maintenance

Consumables for maintenance

Precautions and safety rules when working on a car

Basic tools, measuring instruments and methods of working with them

• Basic set of necessary tools
• Methods of working with measuring devices

The mechanical part of the engine (gasoline engines)

• Check without removing from the car
• Drive (poly-V-belt) belt
• Camshaft (camshaft)
• Cylinder head
• Cylinder head gasket
• Crankshaft seals
• Engine assembly
• Engine block (3ZR engines)

The mechanical part of the engine (diesel engines)

• Check without removing from the car
• Drive (poly-V-belt) belt
• Camshaft (camshaft)
• Cylinder head
• Cylinder head gasket
• Crankshaft seals
• Engine assembly
• Engine block

Cooling system

• Car service
• Cooling fan
• Coolant pump
• Thermostat
• Cooling fan motor
• Radiator

Lubrication system

• Car service
• Oil and oil filter
• Contact oil pressure sensor
• Oil level sensor (models with 2AD engines)
• Oil pump
• Engine oil cooler

Power system

• Car service
• Power system for a gasoline engine
• Diesel engine power system

Engine management system

• Throttle body
• Engine control module (ECM)
• Accelerator pedal
• Sensors of the system

The intake and exhaust system

• Intake manifold
• Exhaust manifold
• Exhaust pipelines and silencers
• Intercooler (models with diesel engines)
• Systems for the reduction of the toxicity of exhaust gases

Engine electrical equipment

• Ignition system (gasoline engines)
• Charge system
• Start-up system
• Preheating system (diesel engines)

Clutch

• Prorolling the clutch slipstream
• Clutch pedal
• Clutch hydraulic circuit, clutch release mechanism
• Clutch

Manual transmission

• Oil for mechanical transmissions
• Gear lever
• Gear shift cable
• Oment of the differential
• Mechanical transmission assembly
• Back light switch

Automatic transmission

• Fluid for automatic transmissions
• Gear lever
• Gear shift cable
• Seals of the differential
• Automatic transmission in the main transmission block
• ТСМ
• Hydrotransformer and master disk
• Valve body assembly

Stepless transmission

• Continuous transmission fluid
• Gear lever
• Gear shift cable
• Omentums of the differential
• Stepless transmission complete
• Hydrotransformer and master disk
• Oil pan

Transfer case

• Transfer case oil
• Transfer box oils
• Transfer case assembly
• All-wheel drive computer

Drive shafts and final drive

• Front drive shafts
• Rear drive shafts
• Propeller shaft
• Rear differential

Chassis

• Front suspension
• Rear suspension
• Wheels and tires
• Axis hubs

Brake system

• Car service
• Brake pedal
• Master cylinder, brake assist, vacuum pump
• Front brakes
• Rear brakes
• Parking brake
• Anti-lock system

Steering board

• Steering wheel, switches on the steering wheel
• Steering column
• Steering, steering rods
• Power steering control module

Body

• General information
• Interior equipment
• External car equipment
• Body dimensions

Passive safety system

• Background
• Precautions when working with the passive safety system
• Airbags
• Central control unit of the SRS system
• Sensors of the SRS system
• Twisted cable
• Disposal of airbag and belt tensioner modules

Air conditioning system

• Background
• Air conditioning control unit
• Sensors of the system
• Air conditioning panel
• Elements of the air conditioning system

Electrical equipment and electrical systems of the car

• Vehicle control and ancillary equipment
• Interior lighting
• Audiovisual system
• Designation of the electrical wiring diagram
• Index of abbreviations on diagrams
• Electroschemes

Explanatory dictionary