This book provides only a description of the repair of the engine 2AZ-FE

To get acquainted and to buy the full book on car repair Toyota Camry / Toyota Avalon / Toyota Solara / Lexus ES 300 / Lexus 330 2002 thru 2005 (including engine) it is possible under the link

Content

Four-cylinder engine

• General information
• Camshafts and valve lifters
• Front crankshaft oil seal
• Crankshaft pulley/damper
• Cylinder head
• Flywheel/ drive disc
• Intake manifold
• Sump
• Oil pump
• Engine mounts
• Rear crankshaft oil seal
• Repairs that can be carried out without removing the engine from the vehicle
• Timing chain and sprocket
• Bringing the piston of the first cylinder to the top dead center (TDC) position
• Valve cover
• Variable Fuel Injection Timing System (PVT)

Six-cylinder V7 engine

• General information
• Exhaust manifolds
• Flywheel/drive disc
• Intake manifold
• Sump
• Oil pump
• Oil seals
• Engine mounts
• Rear crankshaft oil seal
• Repairs that can be carried out without removing the engine from the vehicle
• Toothed drive belt and sprocket
• Setting the piston of the first cylinder to the top dead center (TDC) position
• Valve covers
• Variable fuel injection timing (VVT)

General engine overhaul procedures

• Crankshaft - removal and installation
• Cylinder compression test
• Alternative engine rebuild options
• Engine - removal and installation
• Removing the engine: methods and precautions
• Engine overhaul
• Initial start-up and running-in after overhaul
• Oil pressure test
• Pistons and connecting rods
• Diagnostic checks with a vacuum gauge

Fuel and exhaust system

• Air cleaner
• Electronic fuel injection
• Exhaust system service
• Fuel level sensor
• Fuel lines and connectors
• Fuel pressure regulator
• Releasing fuel pressure
• Fuel surge damper
• Fuel pump/fuel pressure
• Fuel pump
• Receiver and injectors of the fuel system.
• Cleaning and repairing the fuel tank
• Fuel tank
• Throttle block

Emission control and engine management systems

• Camshaft position sensor (CMP)
• Catalytic converters
• Crankshaft Position Sensor (CKP)
• Engine coolant temperature sensor (ECT)
• Exhaust gas recirculation (EGR) system (2002 and 2003 Models with 6-cylinder V7 engine)
• Evaporative emissions assist (EVAP)
• Knock sensor
• Air flow sensor (MAF)
• On-Board diagnostic (OBD) and trouble codes
• Oxygen sensor and air/fuel ratio sensor
• Crankcase ventilation (PCV)
• Engine control module (PCM)
• Throttle position sensor (TPS) and throttle control servo
• Vehicle speed ??sensor (VSS)