Content

Introduction

• How to use this manual
• Identification information
• Repair instructions
• How to troubleshoot ECU controlled systems
• Terms

Maintenance

• Outside vehicle
• Under hood
• Brake
• Chassis

Preparation

Service specifications

Diagnostics

Engine mechanical

• Valve clearance
• Ignition timing
• Idle speed
• Timing belt
• Cylinder head
• Engine unit (2WD)
• Engine unit (4WD)
• Cylinder block
• Exhaust system

Emission control

• Parts layout and schematic drawing
• Positive crankcase ventilation (PCV) system
• Evaporative emission (EVAP) control system
• Three–way catalytic converter (TWC) system
• Secondary air injection system

SFI

• Fuel pump
• Fuel pressure regulator
• Njector
• Fuel tank and line
• Throttle body
• Camshaft timing oil control valve
• Acoustic control induction system (acis)
• Efi main relay
• Fuel pump resistor
• Engine coolant temperature (ECT) sensor
• Knock sensor
• Air–fuel ratio (A/F) sensor
• Heated oxygen sensor
• Vvt sensor
• Accelerator pedal position sensor
• Engine control module (ECM)
• Fuel cut RPM

Cooling

• Coolant
• Water pump
• Thermostat
• Radiator

Lubrication

• Oil and filter
• Oil pump
• Oil cooler
• Oil nozzle

Ignition

• Ignition coil
• Camshaft position sensor

Starting

• Starter
• Starter relay

Charging

• Generator

Automatic transmission (A750E, A750F)

• Atf temperature sensor
• Park/neutral position (PNP) switch
• Valve body assembly
• Parking lock pawl
• Air cooled oil cooler
• Column shift assembly
• Automatic transmission unit
• Torque converter clutch and drive plate

Transfer

• Transfer unit
• Transfer assembly
• Driven sprocket
• Rear output shaft
• Input shaft
• Planetary gear
• One touch 2–4 selector system

Propeller shaft

• Troubleshooting
• Propeller shaft assembly (2WD)
• Spider bearing

Suspension and axle

• Troubleshooting
• Front wheel alignment
• Tire pressure monitor receiver
• Tire pressure monitor valve
• Tire pressure monitor ECU
• Front axle hub
• Front wheel hub bolt
• Front drive shaft
• Front differential rear oil seal
• Front differential carrier
• A.D.D. control system
• Front shock absorber
• Front upper suspension arm
• Front lower suspension arm
• Front upper ball joint
• Front stabilizer bar
• Rear axle shaft
• Rear wheel hub bolt
• Rear differential front oil seal
• Rear differential carrier
• Rear pneumatic cylinder
• Coil spring and rear shock absorber
• Rear lateral control rod
• Rear upper and lower control arm
• Rear stabilizer bar
• Electronic modulated air suspension
• Height control compressor and dryer
• Height control valve
• Rear height control sensor
• Suspension control ECU

Brake

• Troubleshooting
• Brake fluid
• Brake pedal
• Parking brake pedal
• Brake master cylinder
• Brake booster assembly
• Front brake pad
• Front brake caliper
• Rear brake pad
• Rear brake caliper
• Parking brake
• ABS and VSC actuator
• Front speed sensor
• Rear speed sensor

Steering

• Troubleshooting
• Power steering fluid
• Air control valve
• Steering wheel
• Tilt steering column
• Power steering vane pump
• Power steering gear

Supplemental restraint system

• SRS airbag
• Steering wheel pad and spiral cable
• Front passenger airbag
• Side airbag
• Curtain shield airbag
• Airbag sensor
• Front airbag sensor
• Side airbag sensor
• Curtain shield airbag sensor
• Seat position sensor
• Occupant classification ECU
• RSCA off switch
• Wire harness and connector

Body electrical

• Troubleshooting
• Power source
• Power outlet
• Ignition switch and key unlock warning switch
• Headlight and taillight system
• Fog light system
• Turn signal and hazard warning system
• Interior light system
• Back–up light system
• Stop light system
• Wiper and washer system
• Combination meter
• Compass
• Defogger system
• Power window control system
• Power door lock control system
• Theft deterrent system
• Wireless door lock control system
• Power seat control system
• Power mirror control system
• Seat heater system
• Garage door opener system
• Engine immobiliser system
• Horn system
• Trailer towing

Body

• Battery
• SRS airbag
• Rear bumper
• Front door
• Rear door
• Back door
• Front wiper and washer
• Rear wiper and washer
• Body outside moulding
• Roof drip side moulding
• Windshield
• Quarter window glass
• Sliding roof
• Instrument panel
• Roof headlining
• Side step
• Front seat
• Rear seat
• Seat belt
• Seat belt pretensioner

Air conditioning

• Air conditioning system
• Manifold gauge set
• Refrigerant line
• Cooling unit
• Heater unit
• Rear A/C unit
• Blower unit
• Compressor and magnetic clutch
• Receiver
• Condenser
• Rear A/C evaporator
• Rear A/C expansion valve
• Water valve
• Blower motor
• Power transistor
• Air mix servomotor
• Pressure switch
• Relay
• Condenser fan
• Air conditioner control

Operation of instruments and controls

Information before driving your toyota

Starting and driving

In case of an emergency

Corrosion prevention and appearance care

Vehicle maintenance and care

Do–it–yourself maintenance