Content

Introduction

• How to use this manual
• Identification information
• Repair instructions
• How to troubleshoot ecu
• Terms

Preparation

Service specifications

Diagnostics

Clutch

• Troubleshooting
• Clutch pedal
• Clutch master cylinder
• Clutch release cylinder
• Clutch unit

Manual transaxle

• Troubleshooting.
• Manual transaxle unit
• Manual transaxle assembly
• Input shaft
• Output shaft
• Shift and select lever shaft
• Differential case
• Shift lever and control cable

Automatic transaxle

• Automatic transaxle system
• Vehicle speed sensor
• Direct clutch speed sensor
• Neutral start switch
• Valve body assembly
• Differential oil seal
• Shift lock system
• Floor shift assembly
• Automatic transaxle unit
• Torque converter and drive plate

Suspension and axle

• Troubleshooting
• Tire and wheel
• Front wheel alignment
• Rear wheel alignment
• Front axle hub
• Front wheel hub bolt
• Front drive shaft
• Front shock absorber
• Front lower suspension arm
• Front stabilizer bar
• Rear axle hub
• Rear wheel hub bolt
• Coil spring and rear shock absorber
• Rear axle beam

Brake

• Brake system
• Troubleshooting
• Brake fluid
• Brake pedal
• Parking brake lever
• Brake master cylinder
• Brake booster assembly
• Front brake pad
• Front brake caliper
• Rear drum brake
• Rear brake pad
• Rear brake caliper
• Parking brake
• Load sensing proportioning valve
• ABS actuator
• Front speed sensor
• Rear speed sensor

Steering

• Steering system
• Troubleshooting
• Drive belt
• Power steering fluid
• Steering wheel
• Tilt steering column
• Power steering vane pump
• Manual steering gear
• Power steering gear

Supplemental restraint system

• SRS airbag
• Steering wheel pad and spiral cable
• Front passenger airbag assembly
• Side airbag assembly
• Airbag sensor assembly
• Front airbag sensor
• Side airbag sensor assembly
• Wire harness and connector

Body electrical

• Body electrical system
• Troubleshooting
• Power source
• Ignition switch and key unlock warning switch
• Headlight and taillight system
• Headlight beam level control system
• Rear fog light system
• Turn signal and hazard warning system
• Interior light system
• Back-up light system
• Stop light system
• Wiper and washer system
• Combination meter
• Defogger system
• Power window control system
• Power door lock control system
• Wireless door lock control system
• Power mirror control system
• Seat heater system
• Audio system
• Clock

Body

• Clip
• Srs airbag
• Front bumper
• Rear bumper
• Headlight
• Rear combination light
• Hood
• Frontdoor
• Rear door
• Back door
• Front wiper and washer
• Rear wiper and washer
• Body outside moulding
• Roof drip side finish moulding
• Windshield
• Quarter window glass
• Back door glass
• Tilt moonroof
• Sliding roof
• Instrument panel
• Roof headlining
• Front seat
• Rear seat
• Seatbelt
• Seat belt pretensioner
• Roof rail
• Spoiler
• Fuel tank and line

Air conditioning

• Air conditioning system
• Troubleshooting
• Drive belt
• Manifold gauge set
• Refrigerant line
• Air conditioner unit
• Heater unit
• Compressor and magnetic clutch
• Condenser
• Expansion valve
• Blower motor
• Blower resistor
• Air inlet servomotor
• Thermistor
• Pressure switch
• Heater main relay
• Heater sub relay
• Magnetic clutch relay
• Cooling fan relay
• Condenser fan
• Condenser fan resistor
• Air conditioner amplifier
• Heater control assembly
• Water temperature switch
• Air refiner filter